LO1-430

7/27/2019 LO1-430

1/30

3 Series1 Series120 VoltHeated Cabinet

USer ManUal

InterMetro Industries CorporationWilkes-Barre, PA 18705570-825-2741 www.metro.com

L01-430 Rev. C 2/09

Inormation and specifcations are subject to change withoutnotice. Please confrm at time o order.

TM

Metro Heated Cabinets are forHot Food Holding applications only

1 Series

3 Series

7/27/2019 LO1-430

2/30

See Data Plate forElectrical Specifications

MOISTURE

Combination

Module

Holding

Module

See Data Plate forElectrical SpecificationsHOLDING

C05-961

Combination

Module


MOISTURE

Proofing

Module


MOISTURE

C5-PM- 0001000

C05-963

PROOFING

HOLDING INSTRUCTIONS

BASIC CABINET SETUP

CAUTION

A. Refer to DATA PLATE for electrical requirements. Cabinets rated at 120V 2000watts must be plugged into a 125 VAC 20 amp receptacle and must be used on anindividual branch circuit. Cabinets rated at 120V 1440 watts must be plugged intoeither a 15 amp or 20 amp 125 VAC receptacle. DO NOT MODIFY CORD PLUG.

B. With POWER switch OFF, plug into 125 VAC grounded receptacle.

C. Fill water pan to top with clean HOT tap water for Proofing or if moisture is desired

for Holding. Check water level every 3 hours (2 hours when Proofing) and refill withclean HOT tap water as necessary. Water pan does not have to be filled for Holding.Proofing requires water pan to be filled.

1) Set Combination Module switch to HOLD2) Set POWER switch to the ON position.3) Set TEMPERATURE control to 10.4) Set MOISTURE control to 10 (or desired level) on Moisture Module Only.5) Pre-heat cabinet until desired temperature is reached (typical heat-up time from72(22C) ambient to 160(71C) is approximately 45 minutes).6) Re-set TEMPERATURE control and adjust as necessary to reach desiredtemperature (setting 6-8 is typical for 150(66C) to 160 (71C)). Power indicatorlight will turn on and off as the heat thermostat cycles.

1) Set Combination Module switch to PROOF2) Set POWER switch to the ON position.3) Set TEMPERATURE control to 2.4) Set MOISTURE control to 10.5) Pre-heat cabinet until desired temperature and humidity is reached (typicalheat-up time from 72(22C) ambient to 95(35C) and 95% relative humidity isapproximately 30 minutes).6) Adjust settings as necessary to reach desired temperature and humidity levels.Power indicator lights will turn on and off as the heat and moisture thermostats cycle.

3 & 1 S E R IE S

OPERATING INSTRUCTIONS

Breads

Biscuit, Buttermilk Mini 175 (79C)Croissants, Sliced 155 (68C)French Toast, Thin Slice 175 (79C)Waffles, Original 175 (79C)Pancakes 175 (79C)Pizza 175 (79C)Rolls 175 (79C)Dough (Proofing) 90-100 (32-38C)

Meats

Prime Rib 175 (79C)Hamburgers 180 (82C)Hot Dogs 170 (77C)Roast Beef 175 (79C)Roast Pork 175 (79C)Ribs (Pork Spareribs) 175 (79C)

PoultryChicken, Boneless, Skinless 175 (79C)Chicken, Thigh, Baked, Fried 175 (79C)Chicken, Full Breast 175 (79C)Chicken, Drum, Baked, Fried 175 (79C)Chicken, Leg 175 (79C)Chicken, Fried Full Breast 175 (79C)Chicken, Fried Thigh 175 (79C)Chicken, Fried Drum 175 (79C)Chicken, Fried Boneless Skinless 175 (79C)Chicken, Whole Roasted 170 (77C)Turkey 175 (79C)

Vegetables

Broccoli, Spears 175 (79C)Carrots, Sliced, Crinkled 175 (79C)

Cauliflower, Clusters IQF 175 (79C)Corn on the Cob 180 (82C)Mixed Vegetables 175 (79C)

Fry, Regular 3/8" 195 (91C)Potatoes, Mashed 175 (79C)Potatoes, Baked 180 (82C)Potatoes, Scalloped 175 (79C)

Starches

Pasta, Elbow Macaroni 180 (82C)Rice 180 (82C)Lasagna, Meat Sauce & Cheese 185 (85C)Beans 175 (79C)

Fish

Fish, Baked (Cod Loin) IQF 170 (77C)Fish, Batter Dipped 175 (79C)

Developed in conjunction with the Center for Food Innovation (CFI),

Penn State University

F O O D S E T T I N G S G U I D E

2 3 1

2 3

2 3 14

42 3

WATER PAN MUST BE IN PLACE DURING MODULE OPERATION.

UNPLUG CABINET FROM WALL AND ALLOW CABINET (ANDWATER) TO COOL BEFORE CLEANING OR SERVICING.

DO NOT SPRAY OR POUR WATER ON THE MODULE WHENCLEANING AND DO NOT IMMERSE THE MODULE IN WATER.WIPE WITH A DAMP CLOTH AND DRY WITH A TOWEL.

KEEP CABINET AND MODULE CLEAN. ACCUMULATION OFGREASE AND OTHER DRIPPINGS MAY IGNITE.

Moisture

Holding

Module


MOISTURE

C5-PM- 0001000

C05-963

MOISTURE

HOLDING

PROOFING INSTRUCTIONS

2 3 4

Moisture

Holding

Module


MOISTURE

120

volt

7/27/2019 LO1-430

3/30

Table of ConTenTsSection Page

i. Bsoprgudls......isdFrcvr

ii. Syirm..............................................

iii. idyYurcb.................................... 2

iV. isll&S-up........................................... 3

V. PrduFurs............................................... 7

Vi. oprisrus....................................... 8

Vii. cr&M..........................................0

Viii. Bstrublsh.......................................

iX. Srv&RplmPrs............................3

X. Wrry..................................................24,25-26

safeTY InfoRMaTIon WARNING: Fllwlldsyudls.Pr-hhbhdsrdmprurbrpl

d,hdhb.thssr-hrmlzb.Fdmusbhpprprmprurbrbpldhsb.Usdprbhrldmprurhbmprursssrlyhrldmprur.

WARNING: olyrypprvdsrvsshuldmpsrv,rprrrpllrlmps,wrrpwrrd.

WARNING: Upluhbbrlrsrv.Dwshhbwhwrjrhhprssurwr.

WARNING: thsbsrhdhldpplsly.

CAUTION: Dspryrpurwrhmdul.tlhb,wpwhdmplhddrywhwl.Uslylspprvdrlumum.

CAUTION: Wrdrpphrrmpdrsbslphzrd.

7/27/2019 LO1-430

4/302

IDenTIfYInG YoUR CabIneT

PaRT nUMbeRInG

Forfuturereference,recordthecbinetmodelnumber&mnufctureddtefoundonthedteplteloctedtrerofcbinet.alsorecordthemoduleserilnumberloctedinsidethecbinetonmoduletopright-hndcorner.

Mdlumbr:

cbmuurdd:

Mdulsrlumbr:

Mdulmuurdd:

Flludrurhwrryrdldhbhsmul.

C51SERIESCABINETC519HFC4A

caBinetnaMe

caBinettYPe

=Un-inSULateD

caBinetSiZe(HeigHt)9=FULL7=3/45=/2

MoDULec=c5-cM2000,coMBo,2000W.H=c5-HM2000,HoLDing,2000W.P=c5-PM500,PRooFeR,440W.

a=acceSSoRieS

SLiDeS

L=FiXeD,LiPLoaDU=aDJUStaBLe,UniVeRSaL4=FiXeDWiRe

DooRFc=FULLcLeaR

C53SERIESCABINETC539HLDSUBUA

caBinetnaMe

caBinettYPe3=inSULateD

caBinetSiZe(HeigHt)9=FULL7=3/45=/2

MoDULec=c5-cM2000,coMBo,2000W.H=c5-HM2000,HoLDing,2000W.P=c5-PM500,PRooFeR,440W.HL=c5-HM500,HoLDing,440W.cL=c5-cM500,coMBo,440W.M=c5-MM2000,MoiStUReHoLDing,20V-990W.

a=acceSSoRieS

SLiDeSL=FiXeD,LiPLoaDU=aDJUStaBLe,UniVeRSaL4=FiXeDWiRe

DooR(S)FS=FULLSoLiDDS=DUtcHSoLiDFc=FULLcLeaRDc=DUtcHcLeaR

120

volt

PaneLcoLoRBg=Beige BLank=ReDBU=BLUe Sg=SagegY=gRaY gReenoR=oRange YL=YeLLoW

7/27/2019 LO1-430

5/303

InsTallaTIon anD seT-UP. chrShppDm:chhpdbrshppdmruldhu,

drrmvllhp.

2. thrvrhsprdusrspsblrflrhdmlms.thsqupmmusbpdmmdlyrsp.allvsbldmmusbrprdhrhmpywh48hursdmusbdrhbllhmdlvry.

3. clddmsyurrspsblyyumusdvshrrrylssrdmwh5dysrrphb.ihrsdm,rhrlprsprs.

4. aruphb,rmvllpdpmrlrmhsdswllsusdhu.

5. ayprvvrs(plsrpprsh)hshmlrlrdr,pplbl,muslsbrmvdbrurhb.

WARNING:Oy actory approved service aets shoud attempt to service, repair or repace eectricacompoets, wiri or the power cord.

6. Rrhdplhlwrrrhbrhlrlspfs.Whhpwrswh,pluhrd25Vac,60yl,ruddrpl.cbsrd2000wsmusbplud

20-mprpldmusbusddvdulbrhru.cbsrd440wsmybpludhr5mpr20-mprpl.

15AmpOutletFor1440WattCabinets

20AmpOutletFor2000WattCabinets

(1440wattcabinetscanbepluggedinto20Ampoutlet)

CAUTION:A 3 Series cabiet (poymer Isuatio Armour paes o the sides, top ad rear) must ot be pacedext to char broiers. Aow 18" (46cm) betwee the Isuatio Armour ad ay cooki equipmet. Do

ot aow hot kitche equipmet whose suraces exceed 200F (90C) to touch the paes.

WARNING:Do ot aow combustibe materias to be stored or accumuate o, uder or ext to the cabiet.Do ot bock ay vetiatio ouvers or sots.

NOTE:Temperature is dispayed F.

7/27/2019 LO1-430

6/304

3" Pan CaPaCITY UnIVeRsal slIDes(ITEM#17ONREPLACEMENTPARTSLIST,PAGE13)

slIDe InsTallaTIon

thruprhshvbslldhry.i

rmvdrl,rsllbyhhmhrbrshsdwllshb.

InsTallaTIon anD seT-UP (ctiud)

TOPVIEW

FULLHEIGHT 3/4HEIGHT 1/2HEIGHT

UNIVERSALWIRESLIDE

(ITEM#19ONREPLACEMENTPARTSLIST,PAGE13)

120

volt

INDIVIDUALUNIVERSALUPRIGHTS

(ITEM#29ONREPLACEMENTPARTSLIST,PAGE13)

7/27/2019 LO1-430

7/305

CoRReCT oRIenTaTIon of lIP loaDeD slIDes(ITEM#18ONREPLACEMENTPARTSLIST,PAGE13)

InsTallaTIon anD seT-UP (ctiud)

CoRReCT oRIenTaTIon of fIXeD WIRe slIDes(ITEM#16ONREPLACEMENTPARTSLIST,PAGE13)



7/27/2019 LO1-430

8/306

ReVeRsInG THe DooRs

thdryurbbrvrsdmmdrh-rl-hdp.thbhsbshppdwhhhsmudhrh-hdsd.trvrs,llwhsruslsdblw:

. Whhdrhlsdps,rmvhhpbydrvuushmmrddrvprsmlldmrsrwdrvr.

2. ohpsrrmvdrsphdrfrmlydpullhlhlvr,hswllrlshdr.Shdrsdbruldmhs.

3. Rmvhsrwsrmhlsdhbdssd.thrmvhbmudprhhdrmuhlsdhb.Puhsrwsrmvdrmhlsdhbhrmhlshrhsdhb.thllsrwsbrprd.

4. Rlhlhpl(s)rmhlsdhrhbyrmvhwmusrws.thllsrwsbrprd.

5. Rhdr80drsdlhdrmudhprwhhbmudhprdphhpplshphpsushwhphbmudhpr.ivrhdrlhbyrmvhblplssrwvrsdrmvhsrwshldhlhpl.

120

volt

7/27/2019 LO1-430

9/307

PRoDUCT feaTUResthmdulhsbpldhbshbrsyssblydfpr.

clrly-mrdrlplrsyvwllwslmdjusmswhuphdr.

Rmvblwrp.

cbdsdwhdrpruhdhpdsdrpp.

Fldrvrsbl,sddr.

esypulldjusblmdrlh.

crdprrrb.

allmpsdr,mdul,sldrsrrmvblprmhruh,bsru-rl.

7/27/2019 LO1-430

10/308

oPeRaTInG InsTRUCTIonsPower-Up&Pre-Heat

Your C5 1 SerieS or 3 SerieS Cabinet maY be equipped with Several different moduleS:

C51SERIES C53SERIES coMBinationPRooF&HoLDMoDULe coMBinationPRooF&HoLDMoDULe HoLDingMoDULe HoLDingMoDULe PRooFingMoDULe PRooFingMoDULe MoiStUReHoLDingMoDULe

a. RrhDataPLaterlrlrqurms.2000wbsrqur20mpdvdulrudrpl.cbsrd440wsmybpludhr5r20mprpls. DONOTMODIFYCORDPLUG.

B. WhPoWeRswhoFF,plu25Vacruddrpl.

c. Fllhwrp/2"rmhpwhlHotpwrrPrfrmsursdsrdrHld.chwrlvlvry3hurs(2hurswhPrf)drfllwhlHotpwrsssry.WrpdshvbflldrHld.PrfdMsurHldMdulrqurwrpbflldmsurrlsurd.

HOLDINGINSTRUCTIONS) ScmbMdulswh

HOLD.

2) SPoWeRswhhONps.

3) SteMPeRatURerl10.

4) SMoiStURerl10.

5) Pr-hbuldsrdmprursrhd(yplh-upmrm72F(22c)mb60F(7c)spprxmly45mus).

6) R-steMPeRatURerlddjussssryrhhdsrdmprur(s6-8yplr50F(66c)60F(7c)).Pwrdrlhwllurdshhhrmsyls.

7) adjusMOISTURErldsrd

lvl(0bhhslvl,lwslvl,OFFbhhwr).thdrlhswllurdshhdmsurhrmssyl.

PROOFINGINSTRUCTIONS) ScmbMdulswh

PROOF.

2) SPoWeRswhhONps.

3) SteMPeRatURerl2.

4) SMoiStURerl10.

5) Pr-hbuldsrdmprurdhumdysrhd(yplh-upmrm72F(22c)mb95F(35c)d95%rlvhumdyspprxmly30mus).

6) adjussssssryrhhdsrdmprurdhumdylvls.Pwrdrlhswllurdshhdmsurhrmssyl.

7) adjusMOISTURErldsrdlvl(0bhhslvl,lwslvl,OFFbhhwr).thdrlhswllurdshhdmsurhrmssyl.

Whhpwrswhs,hblwrslwysrzd,rulr,dhdlhrmmrslwysdsplyhbmprur.Whhhrmsssshsrqurd,hpprprdrwlllhdhhrlmwllbprduh.

MoistureHolding

Module

MOISTURE

HOLDING

MOISTURE

HOLDINGMoistureHolding

Module

120

volt

7/27/2019 LO1-430

11/309

ahdhprdy,sssrydsruphmprursurhb.Byswhhpwrswh,hbslrpr.Whrsumprs,swhhpwrdhbwllhprvusmprurdmsurlvls. CAUTION:The water pa must be i pace duri modue operatio. CAUTION:Water iside this cabiets pa is hot duri use! Tur o ad aow the water to coo beore emptyi

the pa.

NOTE:The POWER switch is ot a oot switch. Usi it as a oot switch ca damae the switch ad make thecabiet ioperabe.

WARNING:Foow a ood saety uideies. Preheat the cabiet to the desired temperature beore putticooked, hot ood ito the cabiet. This is ot a rethermaizatio cabiet. Food must be at theappropriate temperature beore bei paced ito this cabiet.

Yurc5Srsr3Srsbspblrsmhumdr.asyuprhbdpdlshdr(s),dsmyrmhsdsurshb.Smdrppwrmyurhusdhbprulrlyhdrsls.Wrmylsdrppddrshr.

CAUTION:Water drippi oto the oor rom ope doors ca be a sip hazard. NOTE:Whe turi the cabiet o at the ed o the workday, it is recommeded to eave the door(s) ope to

prevet heat ad codesatio buid up withi the cabiet.

fooD HolDInG GUIDelInesA.C5-CM2000/C5-HM2000A.C5-CM1500/C5-HM1500

RecommendedFoodHoldingGuidelines FoodProduct Covered/Uncovered TemperatureSetting*

BdFsh Uvrd 75F(79c)

BdPs Uvrd 80F(82c)

Bsu Uvrd 80F(82c)

Brl cvrd 70-75F(77-79c)

chnus Uvrd 75F(79c)

crhcb cvrd 70-75F(77-79c)

crsss Uvrd 75F(79c)

ePs cvrd 80F(82c)

FrhFrs** Uvrd 85F(85c)

Frdch Uvrd 80-85F(82-85c)

FrdFsh Uvrd 80F(82c)

Hmburrs cvrd 80F(82c)

Ls cvrd 85F(85c)

MshdPs cvrd 75F(79c)

MxdVs cvrd 70-75F(77-79c)

Ps cvrd 75F(79c)

Ps cvrd 80F(82c)

Ps cvrd 70-75F(77-79c)

Pzz Uvrd 75-80F(79-82c)

RsB Uvrd 70-80F(77-82c)

RsPr Uvrd 70-80F(77-82c)

SllpdPs cvrd 75F(79c)

SrpS Uvrd 60-70F(7-77c)

tury Uvrd 70-80F(77-82c)

Ws cvrd 75F(79c)

Whlch Uvrd 70-80F(77-82c)

*tmprursrudlsly,bsdpbdrsvry5mus.**Lhlysldrbsquly. DvlpdbyPSUvrsyShlHl,Rsur,dRrMm

7/27/2019 LO1-430

12/300

CaRe & MaInTenanCeCleaningTheCabinet

WARNING: Upu the cabiet beore ceai or servici. Do ot wash the cabiet with a water jet or hih-pressure water.

WARNING:Aow the uit to coo beore ceai, as the iterior o the cabiet may be hot eouh to bur. Aso,aow the water i the pa to coo beore remova.

CAUTION:Do ot spray or pour water ito the cotro modue. To cea the cabiet ad modue, wipe with a dampcoth ad dry with a towe. Use oy ceai aets approved or aumium.

CAUTION:Do ot use stro akais as it may discoor aumium.

Uslrshprprrs.Fllwhmuurrsdrsrhlprduusd.arusylprdus,hruhlyrsllsursrmvllrsdu.

Usdmplhrsp.Mldspsublrlumumspbl.Drywhlwl.Wpupspllsssspssbldrulrlylhbvdsddfullds.

irlbdsbrmvdrl,rmvhb,lhbrssdb,drplhb.

. Msurhpwrrdsnothdhrdpr.ophdr(s).ihrswrhp,rmvdmpy.Rmvhmdulrmhbbyluphruhlrsd,dhpullhmdulwyrmhb.thpwrrdslpshruhhlrhlhrrhb.

2. Rmvhsldrs.3. arl,rplllmps.Msurhsldrsrsdhhrsrrly.

4. Pushhpwrrdhruhhplsspbushhrrhbdsllhmdul.

CLEANINGINSTRUCTIONSorCLEAR,POLYCARBONATEDOORS(iapplicable):

thprvmshplyrbdrmybrmvdbysmplyplrmhdr,srprrdwrdwwrd.Frrulrl,sllhdlrrmmddbysmuurrrusplyrbplssssusd.Dussyhlhsrlrsddrplyrbplssshswllsrhddullhplyrbdrpl.addlhsrphdrplldlr:

. isprpyl(rubb)lhl,usdslr,wlldrmvrssmudsdfrprs.

b. asmllmulquddshdrbuwrwllhlprmvhvrdrdwllhlpmh

lrplsdhrrlssllyrdus.. aps-wxrmmddrplyrbplssdpprvdrdsrvqupmwllhdsmll

srhsdrurhlusrdlryhlrdrplswllsrduhlrsrdus.

CLEANINGINSTRUCTIONSor3SERIESINSULATIONARMOURPANELSONSIDES,TOPANDBACk:

Usslh,mldspwrslullhly-sldsurs.thwpdrywhl,slh.Frhvly-sldrs,ussbrushdslvrmuls-bsdlr.alwyssurhlrsrmmddrusplssdllwysplsrusrmhmuurr.

120

volt

7/27/2019 LO1-430

13/30

basIC TRoUblesHooTInGModuleoperationbasics:Whhpwrswhs,hblwrslwysrzd,rulr,dhdlhrmmrslwysdsplyhbmprur.ahrmsrlswhhrlmwllbrzddpdhhrmssdhrmprursss.thrlbsusdhhhrmss.Whhrmsssshmprurhsblwssp,hhrmssls,hpprprdrwlllhdhhrlmwllbprduh.Whhhrmsssshmprurhsrhdssp,hsp,hdrlhwlludhhrlmwllspprduh.

HoldingModule:thhldmdulhshlm.ishrdudhsuphrssruldhb.thhrmsssshrurrmprurdwllrzhrdulmsrqurdhuphbr.Smmsurbrdudbyfllhwrpwhwrmwrdllwhwrmrpuphwrvprshblwrrulshr.thrshlmhhwr.

MoistureHoldingandProofngModule:thrrwhlmshsmduls.oshrduhhr,dsudrhwrphhwrdrdumsurhb.ohrmsssshrurrmprurdwllrzhrdulmsrqurdhuphbr.thhrhrmsssshrmprurrudhwrp.iwllrzhwrplmhhwrdrlsmsurhb.

CombinationProoandHoldModule:ambprdhldmdulhsmdswh,whhllwshmdulshrhldmdulrprfmdul.thrr,hsllhlmsbhhld

mduldprfmdul.WhhmdslrswhssHoLD,lyhlrrwrlmsusd.thwrplmsusd.WhhmdslrswhssPRooF,hlwrwrlmdhwrplmrusdbudpdlyrlldbydvdulhrmss.ShpprprprrphbvrmrdlhwhcmbPrdHldMdulprshrhldrprfmd.

elmwsrshwhhrblw:

20mp,2000wb 5mp,440wb

arDulm WrPlm arDulm WrPlm

cmbmdul 950wd675w 675w 360wd675w 675w

Hldmdul 950w 360w

Prfmdul 675w 675w

MsurHldmdul 360w 590wNote:The amp draw or the bower ad diita thermometer is approximatey 0.8 to 0.9 amps. Add the appropriate

amp draw per the eemet chart above whe a eemet(s) is eerized.

WARNING:Oy actory approved service aets shoud attempt to service, repair or repace eectrica compoets,wiri or power cord.

1.Controlsdonotwor(digitalthermometerandindicatorlight(s)notlit): . chhhbsplud. b. chhhulhspwr.islrlsrvusblwrrubrrrppd? . chhhpwrswhshops. d. chhbwrrmhpwrrdhpwrswhdhrmlbl. . Pwrswhuldbbd.

2.Temperaturetoohot: . tmprurspshh.turrlbdwlwrs.Wsvrlmusds hdsplydmprurdrss. b. thrmsmyhvldwhslsd.chhrms. . idsplydmprurxds220F(04c): . Blwrwrsulyrdsd. .Blwrdsrpl.chblwr. . thhrmsrblwrmyhvlddhhrmlvrlddvsrllhmprur. Spushbmmdlydrypprvdsrv.3.Temperaturetoolow: . thbmysllbpr-hrrvrrmdrbpd. b. tmprurspslw.turmprurrlbhhrs.Wsvrlmusd shdsplydmprurrss. . adrslsdrslprprly.

7/27/2019 LO1-430

14/302

d. Blwrsrulr: . Blwrwrsulyrdsd. . Blwrdsrpl.4.Indicatorlightisnotworing:

isrrhdrlhwllbdvbuspssbl.thhrmssmybls dhrrhhrlmsbrzd.chhhrmsdpllhdhr rspvwr.

5.Noheatgenerated: .ihhdrlhs,buhbdsdrwhpprprmprprhhr p: . arhrlmmybuly. . thwrhrhrlmmybulyrdsd. . thhrmsmybuly. b.ihhdrlhs,hhrmssmyblsdhrrhhrlm sbrzd.isrrhhdrlhwllbdvbuspssbl.chhhrms dpllhdhrrspvwr.

6.Moisturelevelistoolow: .ihhdrlhs,dhbdrwshpprprmprprhhrp: .chhhwrphswr. .adrslsdrslprprly. . Msurspslw.turmsurrlbhhrs. b.ihhdrlhs,buhbdsdrwhpprprmprprhhr p:

.arhrlmmybuly. . thwrhrhrlmmybulyrdsd. . thhrmsmybuly. .ihhdrlhs,hhrmssmyblsdhrrhhrlm sbrzd.isrrhhdrlhwllbdvbuspssbl.chhhrms dpllhdhrrspvwr.

7.CabinettripsGFCI(groundaultcircuitinterrupter):agFcirplprssrudulswhvrlrlprduspludhgFciulbyslymrhlryrylssurr.ihurrwuhrpldrsbysmllmurmhrur,hgFciqulyswhspwrhru.thgFcirrupspwrxrmlysmmzhpssblylrsh. .thhrlmmybsrbsmmsurssdsuldurshpmrdurl

prdsbusd(suhsdurhsummrlsdshlh).Pluhb(whu

wrhwrp)-gFciul,shmprur0dlrur30-60musdryuymsurhlmmyhvbsrbd.(irpshsdrdrubrrllrypprvdsrv.)ardryhlm,pluhbhgFciul;hbshuldruwhurpphgFci.

b.ihbsllrpshgFci,llrypprvdsrv.

120

volt

7/27/2019 LO1-430

15/303

seRVICe d RePlaCeMenT PaRTsC51&3SERIESCABINETSItem# ReplacementPartNo. Description

CABINETBODY

1 RPc5-9-FcDR coMPLeteFULLHeigHtcLeaRDooR RPc5-7-FcDR coMPLete3/4HeigHtcLeaRDooR RPc5-5-FcDR coMPLete/2HeigHtcLeaRDooR RPc5-39-tcDR coMPLetetoPcLeaRDUtcHDooR RPc5-39-BcDR coMPLeteBot.cLeaRDUtcHDooR

2 RPc5-39-FSDR coMPLeteFULLHeigHtSoLiDDooR RPc5-37-FSDR coMPLete3/4HeigHtSoLiDDooR RPc5-35-FSDR coMPLete/2HeigHtSoLiDDooR RPc5-39-tSDR coMPLetetoPSoLiDDUtcHDooR RPc5-39-BSDR coMPLeteBot.SoLiDDUtcHDooR

3 RPc4-9 DooRHinge(QtY.)

4 RPc4-8 DooRLatcH,oFFSetHanDLe RPc4-8a DooRLatcH,FLUSHHanDLe

5 RPc06-90a FULLHeigHtcLeaRDooRgaSket RPc06-90B 3/4HeigHtcLeaRDooRgaSket RPc06-90c /2HeigHtcLeaRDooRgaSket RPc06-90D cLeaRDUtcHDooRgaSket

6 RPc06-96a FULLHeigHtSoLiDDooRgaSket RPc06-96B 3/4HeigHtSoLiDDooRgaSket RPc06-96c /2HeigHtSoLiDDooRgaSket RPc06-96D SoLiDDUtcHDooRgaSket

7 B5DnB 5"BRakecaSteR RPQc02-248 6"BRakecaSteR

8 B5Dn 5"SWiVeLcaSteR B5DnR 5"RigiDcaSteR RPQc02-247 6"SWiVeLcaSteR

9 RPc5-SSLeg- StationaRYeQUiPMentLeg(QtY.)

10 RPc5-DPtRH PoLYDRiPtHRoUgH&ScReWS

11 RPc06-79 DRiPPan

12 RPc5-RHanDLe ReaRHanDLe&ScReWS (USeDonLYonSeRieS)

13 RPc5-tRVL tRaVeLLatcH

14 RPc5--BMPR SeRieScoRneRBUMPeRS (2FRont,2ReaR&ScReWS)

15 RPc3-06 PoWeRcoRDBUSHing

16* c5-3-FW-9 FULLHeigHtFiXeDWiReSLiDeS c5-3-FW-7 3/4HeigHtFiXeDWiReSLiDeS c5-3-FW-5 /2HeigHtFiXeDWiReSLiDeS

17* c5-3-U-9 FULLHeigHtUniVSLiDeS&UPRigHtS c5-3-U-7 3/4HeigHtUniVSLiDeS&UPRigHtS c5-3-U-5 /2HeigHtUniVSLiDeS&UPRigHtS

18* c5-3-L-9 FULLHeigHtLiPLoaDSLiDeS c5-3-L-7 3/4HeigHtLiPLoaDSLiDeS c5-3-L5 /2HeigHtLiPLoaDSLiDeS

19 c5-USLiDecPR cHRoMeUniVWiReSLiDeSPaiR c5-USLiDeSPR SSUniVeRSaLWiReSLiDeSPaiR

20 c5-SHeLF acceSSoRYSHeLF (USeDWitHUniVeRSaLUPRigHtS)

Item# ReplacementPartNo. Description

OUTSIDEPOLYPANELSONC53SERIESCABINETS

23 RPc3-tPnL-Bg BeigetoPPaneLincLUDeSScReWS RPc3-tPnL-BU BLUetoPPaneLincLUDeSScReWS RPc3-tPnL-gY gRaYtoPPaneLincLUDeSScReWS RPc3-tPnL-Re ReDtoPPaneLincLUDeSScReWS24 RPc3-SD27-Bg Beige27"SiDePaneL

incLUDeSScReWS RPc3-SD27-BU BLUe27"SiDePaneL

incLUDeSScReWS RPc3-SD27-gY gRaY27"SiDePaneL

incLUDeSScReWS RPc3-SD27-Re ReD27"SiDePaneL

incLUDeSScReWS25 RPc3-SD2-Bg Beige2"SiDePaneL

incLUDeSScReWS RPc3-SD2-BU BLUe2"SiDePaneL

incLUDeSScReWS RPc3-SD2-gY gRaY2"SiDePaneL

incLUDeSScReWS RPc3-SD2-Re ReD2"SiDePaneL

incLUDeSScReWS26 RPc3-ia-BtPnL BottoMSiDePaneL

incLUDeSScReWS

27 RPc3-ia-RtnR MiDDLePaneLRetaineRincLUDeSScReWS

28 RPc5-3-BaSecLPBottoMPaneLcLaMP&ScReWS

29 RPc53-5URt* FULL&/2HeigHtUniVUPRigHtS (QtY.) *(Fullheightcabinetusessameuprights) RPc53-7URt 3/4HeigHtUniVUPRigHtS(QtY.)

30 RPc59-Pkg FULL&3/4HeigHtanD3SeRieS caBinetRetURnPackaging RPc55-Pkg /2HeigHtanD3SeRieS caBinetRetURnPackaging

*Sps4d5rslddf.allsldssldprs.Uvrslsldsluduprhs.

7/27/2019 LO1-430

16/304

seRVICe d RePlaCeMenT PaRTs (ctiud)C51&3SERIESCABINETMODULES

MOISTURE

MODULETYPE: COMBOHOLDING PROOFER COMBOHOLDING HOLDING

MODULEELECTRICALRATING: 1990W 1990W 1440W 1440W 1440W 2000W

ITEM# PART# DESCRIPTION QTY QTY QTY QTY QTY QTY

30 RPc3-27 PoWeRSWitcH(ReD)

31 RPc3-28 SeLectoRSWitcH(WHite) n/a

32 RPc06-93 tHeRMoStatknoB 2 2 2 2

33 RPc3-234 tHeRMoStat 2 2 2 2

34 RPc09-23 tHeRMoStatMoUntingcUP 2 2 2 2

35 RPc3-246 aMBeRinDicatoRLigHt 2 2 2 2

36 RPc3-237 DigitaLtHeRMoMeteR

37 RPc3-83 tHeRMoMeteRtRanSFoRMeR

38 RPc-9 BLoWeRintakecoLLaR

39 RPHM20-203 BLoWeR

40 RPc3-238 HeateLeMent,MSHaPeD,950W n/a

40A RPc3-239 HeateLeMent,MSHaPeD,360W

41 RPc3-236 HeateLeMent,USHaPeD,675W 2 2 2 n/a

42 RPc3-98 tHeRMaLcUt-oUt

43 RPc3-099 PoWeRcoRD,20a

43A RPc3-07 PoWeRcoRD,5a n/a

44 RPc3-098 StRainReLieFBUSHing,20acoRD

44A RPc3-083 StRainReLieFBUSHing,5acoRD n/a

45 RPc3-096 teRMinaLBLock

46 RPc07-055 gRoMMet 2

47 RPc56-ScLP SenSoR&BULBcLaMPkit

48 RPc-85 SSWateRPan

49 RPc06-206 SteMBUMPeR,MoDULeStoP 2 2 2 2 2 2

50 RPc3-290 HeateLeMent,USHaPeD20V,590W

REPLACEMENTMODULES

51 RPc5-cM2000 RePLaceMentcoMBo,20V,990WMoDULe

52 RPc5-HM2000 RePLaceMentHoLDing,20V,990WMoDULe

53 RPc5-PM500 RePLaceMentPRooFing,20V,440WMoDULe

54 RPc5-cM500 RePLaceMentcoMBo,20V,440WMoDULe

55 RPc5-HM500 RePLaceMentHoLDing,20V,440WMoDULe

56 RPc5-MM2000 RePLaceMentMoiStUReHoLDing,20V,990WMoDULe

120

volt

7/27/2019 LO1-430

17/305

*Sps4d5rslddf.allsldssldprs.

seRVICe d RePlaCeMenT PaRTs (ctiud)

C51SeriesCabinetReplacementPartsDiagram

FoRRetURncaBinetPackagingSeeiteM#30,Page3.

10

11

3

15

14

8

9

7

20

12

5

13

4

1

7/27/2019 LO1-430

18/306

seRVICe d RePlaCeMenT PaRTs (ctiud)

*Sps4d5rslddf.allsldssldprs.

C53SeriesCabinetReplacementPartsDiagram

120

volt

FoRRetURncaBinetPackagingSeeiteM#30,Page3.

23

NOTE:Repacemet paesare ordered by coor.See chart o pae 13.

7 11

10

8

28

27

4

2

1OR

6

5

OR

2524 OR

3

15

26

13

7/27/2019 LO1-430

19/307

seRVICe d RePlaCeMenT PaRTs (ctiud)C5-CM2000ORC5-CM1500COMBOMODULE

FoRRePLaceMentc5-cM2000MoDULe,oRDeRiteM#5onPage4

FoRRePLaceMentc5-cM500MoDULe,oRDeRiteM#54onPage4

49

41

47

3941

4237

33

45

3132

32

30

34

34

47

46

48

40

40AOR

38

44A44 OR

43A43 OR

36

BottoMcoVeR

aiRDUct

WateRPanencLoSURe

aiRDiScHaRgecoVeR

intakecoVeR

contRoLPaneL

MoDULecHaSSiS

MoiStURetHeRMoStatBULB

HeattHeRMoStatBULB&tHeRMoMeteRSenSoR

35

7/27/2019 LO1-430

20/308

seRVICe d RePlaCeMenT PaRTs (ctiud)C5-HM2000ORC5-HM1500HOLDINGMODULE

40

40AOR

120

volt

49

39 37

3345

48

BottoMcoVeR

47

46

44A44 OR 43A43OR

aiRDiScHaRgecoVeR

4236

3230

34

38

WateRPanencLoSURe

aiRintakecoVeR

contRoLPaneL

MoDULecHaSSiS

aiRDUct

FoRRePLaceMentc5-HM2000MoDULe,oRDeRiteM#52onPage4

FoRRePLaceMentc5-HM500MoDULe,oRDeRiteM#55onPage4


35

7/27/2019 LO1-430

21/309

seRVICe d RePlaCeMenT PaRTs (ctiud)C5-PM1500PROOFINGMODULE

49

41

47

3941

4237

33

45

32

32

30

34

48

38

44A43A

BottoMcoVeR

aiRDUct

WateRPanencLoSURe

aiRDiScHaRgecoVeR

aiRintake

coVeR

contRoLPaneL

MoDULecHaSSiS


36

FoRRePLaceMentc5-PM500MoDULe,oRDeRiteM#53onPage4

HeattHeRMoStatBULB&tHeRMoMeteR

SenSoR

35

7/27/2019 LO1-430

22/3020

120

volt

seRVICe d RePlaCeMenT PaRTs (ctiud)C5-MM2000MOISTUREHOLDINGMODULE

FoRRePLaceMentc5-MM2000MoDULe,oRDeRiteM#56onPage4

49

50

47

39

4237

33

45

3132

32

30

34

34

47

46

48

40

38

44

43

36

BottoMcoVeR

aiRDUct

WateRPan

encLoSURe

aiRDiScHaRgecoVeR

intakecoVeR

contRoLPaneL

MoDULecHaSSiS



35

7/27/2019 LO1-430

23/302

seRVICe d RePlaCeMenT PaRTs (ctiud)WIRINGDIAGRAM

C5-CM2000ORC5-CM1500COMBOMODULE

19"

BLK

19"

WHT

27" WHT

10"BLK

16"

BLK

25"BLK

10"BLK

25"

BLK

34"

BLK

1360 OR 1950 W ELEMENT

EE

19

19

Z

Z

8

A

2

8

20

3

23

22

MASTER

POWER

SWITCH

HEAT

THERMOSTAT

AMBER

LIGHT

THERMOMETER

TRANSFORMER

24

10

17 13

23

22

21

20

7

10

23

4

17

1824

23

12

11

6

5

22

21

20

19

10

9

8

7

16

15

14

13

4

3

2

1

TERM BLOCK

Z

7WHITE

BLACK

GREEN

GRN GROUND SCREWPOWER CORD 20A FOR C5-CM2000

15A FOR C5-CM1500

STRAIN RELIEF

13

1

AIR DUCT

THERMAL CUT-OUT

THERMOMETER SENSOR

HEAT THERMOSTAT BULB

BLOWER MOTOR

1

30"BLK

30" BLK

25" WHT

30"

BLK

8.50"

BLK

10"

BLK16"

BLK

25"

BLK

19"BLK

10"

BLK

16"BLK16" BLK

675 W ELEMENT

675 W ELEMENT

MOISTURE

THERMOSTAT

BULB

WATER PAN ENCLOSURE

MOISTURE

THERMOSTAT

AMBER

LIGHT

TOP OF MODULE

8

B

C

21

4B

8

CONTROL PANEL

19

8

8

24

XX

X X

SELCTOR

SWITCH

E

D

C

17

17

E

B

B

BA

7/27/2019 LO1-430

24/3022


C5-HM2000ORC5-HM1500HOLDINGMODULE

STRAIN RELIEF

A

3

10

24

POWER CORD 20A FOR C5-HM2000

15A FOR C5-HM1500 GRN GROUND SCREW

GREEN BLACK

WHITE

BLOWER MOTORHEAT THERMOSTAT BULB

THERMOMETER SENSOR

THERMAL CUT-OUT

1360 OR 1950 WATT ELEMENT

AIR DUCT

TERMINAL BLOCK

TRANSFORMER THERMOMETERAMBER

LIGHT

HEAT

THERMOSTAT

MASTER

POWER

SWITCH

TOP OF CONTROL PANEL

1

2

3

4

13

14

15

16

7

8

9

10

19

20

21

22

5

6

11

12

23

24

18

17

4

3

2

10

1

20

21

22

23

24

1917

1

Z

2

19

17

20

Z

22

23

4

21

3

A

25"

BLACK

8.50"

BLACK10"

BLACK

10"

BLACK

16"

BLACK

30"

BLACK

30"

BLACK

30"

BLACK

19"

BLACK

25"

BLACK

19"

WHITE

25"

WHITE

16"

BLACK

25"

BLACK

A

A

17

120

volt

7/27/2019 LO1-430

25/3023


C5-PM1500PROOFINGMODULE

T2

20

3

23

22

MASTER

POWER

SWITCH

HEAT

THERMOSTAT

AMBER

LIGHTTHERMOMETERTRANSFORMER

24

10

17 13

23

22

21

20

7

10

23

4

17

18

24

23

12

11

6

5

22

21

20

19

10

9

8

7

16

15

14

13

4

3

2

1

TERMINAL BLOCK

Z

7WHITE

BLACKGREEN

GRN GROUND SCREW

POWER CORD

STRAIN RELIEF

13

1

AIR DUCT

THERMAL CUT-OUT

THERMOMETER SENSOR


BLOWER MOTOR

1

8

10"

BLACK

30"

BLACK

30"

BLACK

27"

BLACK

19"

WHITE

25"

WHITE

30"

BLA

8.50"

BLACK

10"

BLACK

16"

BLACK

25"

BLACK

19"

BLACK

10"

BLACK

16"

BLACK16"

BLACK

16"

BLACK

25"

WHITE

17

A

2

A A

27"

WHITE9"

BLACK

675 W ELEMENT

675 W ELEMENT

MOISTURE THERMOSTAT BULB

WATER PAN ENCLOSURE

MOISTURE

THERMOSTAT

AMBER

LIGHT

8

8

T2

21

4

T2

T2

19

Z

19

7/27/2019 LO1-430

26/3024


C5-MM2000MOISTUREHOLDINGMODULE

21

T2

MOISTURE

THERMOSTAT

CONTROL PANEL

4

TOP OF MODULE

AMBER

LIGHT

MOISTURETHERMOSTAT BULB

120V 1360W ELEMENT

10"

BLACK

27"

WHITE

17

25"

WHITE

16"

BLACK

16"

BLACK16"

BLACK

10"

BLACK

19"

BLACK

25"

BLACK

16"

BLACK

10"

BLACK

8.50"

BLACK

30"

BLACK

25"

WHITE

27"

BLACK

30"

BLACK

30"

BLACK

8

1

BLOWER MOTOR


THERMOMETER SENSOR

THERMAL CUT-OUT

AIR DUCT

1

13

STRAIN RELIEF

POWER CORD 125VAC 20A

GRN GROUND SCREW

GREEN BLACK

WHITE 7

Z

TERMINAL BLOCK

1

2

3

4

13

14

15

16

7

8

9

10

19

20

21

22

5

6

11

12

23

24

18

17

4

3

2

10

7

20

21

22

23

1317

10

24

120V TO

12V DC TRANSFORMER

THERMOMETER

AMBER

LIGHT

HEAT

THERMOSTAT

MASTER POWER

SWITCH

22

23

3

20

10"

BLACK

120V ,590W ELEMENT

WATER PANENCLOSURE

3

3

T2

T2

A

A

2

27"

WHITE

27"

BLACK

CC

7/27/2019 LO1-430

27/3025

InterMetro Industries Corporation (hereinafter referred to as Seller ) warrants to the

7/27/2019 LO1-430

28/30

7/27/2019 LO1-430

29/30

CUTAlOngD

OTTED

lInE

CUT AlOng DOTTED lInE

CUSTOMERINFORMATION

1.Whichoneotheollowingbestdescribesyourestablishment?

a. Fu-Service Restaurat

b. Baquet Ha

c. Hote/Mote

d. Hospita/nursi Home

e. Coee/Uiversity

. Schoo

. Empoyee Feedi

h. Other

Thak you or purchasi a Metro C5 Cotroed Temperature Cabiet.We are certai you wi be more tha satisfed with its quaity adperormace. Pease f i the warraty iormatio space beow

so we may reister your warraty. Aso, so that we may earmore about our customers ad hopeuy be o cotiued

service i the uture, pease take a momet tof i the customer iormatio space beow.

Thank You

WARRANTYINFORMATION:

Cabiet Mode no.Cabiet Seria no.

Date Purchased

Customer name

Address

Phoe no.

f y cg, s cs m.

2.Pleaseindicatethetwoproductbeneftsthatwereomajorinteresttoyou.

a. Easy-to-use cotros

b. Door seectio

c. Size Seectio

d. Cabiet capacity

e. Side seectio

. Easy-to-cea desi

. Other

FOlD HERE DO nOT DETACH

3.Mainactorthatledtoyourdecisiontopurchasethisproduct?

a. Product operati ad uctioa eaturesb. Overa quaity

c. Price

d. Avaiabiity

e. Other

4.Threesourcesthatledtothepurchaseohisproductintheorderotheirimpact(1beingmostimpact;3beingleastimpact).

a. Trade Joura Ad

b Trade Show

c. Saes Ca

d. Direct Mai

e. Previous Purchase

. Other

7/27/2019 LO1-430

30/30

FOlDHEREDOnOTDETACH

STAPlE

HERE

PosTageWillBePaidBY

INTERMETROINDUSTRIESCORPORATION

ATTn:CUSTOMERSERvICE

POBOxA

WIlKES-BARREPA18705-9968

nOPOSTAgE

nECESSARy

IFMAIlED

InTHEUnITEDSTATES

BUSINESSREPLYMAILFIRST-ClASTAInlESSSTEElPERMITnO.121WIlKES-BARRE,PA

LO1-430

Documents

Transcript of LO1-430